COCKPIT
1. SWITCHES OFF
2. INSTRUMENT PANEL SECURE
3. STICK FREE & FULL
MOVEMENT
4. THROTTLE FREE & FULL
MOVEMENT
5. SEAT ADJUST
6. TRIM TAKE OFF
PRE START UP & START UP CHECKS
1. SECURITY, HARNESSES, DOORS SECURE
2. SWITCHES OFF
3. THROTTLE FREE MOVEMENT & CLOSED
4. ALL CLEAR BEHIND PROP CHECK
5. FUEL TAP OPEN
6. CHOKE (COLD CONDITIONS) SET
7. MASTER SWITCH ON
8. FUEL PUMP ON (10 SECS)
9. CLEAR PROP SHOUT
10. IGNITION START
11. MAGNETOS BOTH
12. RPM 1200 (4 - 5 MINUTES)
13. OIL PRESSURE CHECK IN
GREEN WITHIN 5 SEC IF NOT SHUT DOWN
START UP & WARM UP 525 KPa
14. OIL TEMPERATURE 15° C AND
RISING
15. RADIO ON
16. RPM 2200
17. MAG DROP 100 RPM
NOTE:
APPLY FULL POWER WHEN CHT HAS REACHED
100°C
NEVER ALLOW CHT TO RISE ABOVE 150°C ON
THE GROUND
PRE TAXI & TAXI CHECKS
1. CONTROLS FULL & FREE
2. HARNESS SECURE
3. INSTRUMENT & IGNITION CHECK
4. FUEL STATUS & ON
5. TRIM SET TAKE OFF
6. BRAKES CHECK
7. NOSE WHEEL CHECK FREE & FULL
8. COMPASS CHECK
9. TURN & SLIP CHECK
PRE TAKE OFF & TAKE OFF CHECKS
1. CONTROLS FULL & FREE
2. HARNESS SECURE
3. DOORS SECURE
4. INSTRUMENT SCAN
5. FUEL CHECK
6. FUEL PUMP ON
7. TRIM SET TAKE OFF
8. WIND DIRECTION CHECK
9. RUNWAY & APPROACH CLEAR
10. FULL POWER CHECK
11. CLIMB AT FULL RPM 3300
12. SPEED 55 KTS
13. OIL PRESSURE CHECK
A. NORMAL OPERATIONS MIN 220 KPa
B. NORMAL OPERATIONS MAX 525 KPa
C. DLE MIN 80 KPa
D. START UP & WARM UP 525 KPa
14. OIL TEMPERATURE CHECK
A. MIN 15°C
B. MAX 118°C
C. CONTINUOUS 80-100°C
15. CYLINDER HEAD TEMPERATURE CHECK
A. MAX CHT 175°C
B. CRUISE CHT 150°C
16.AT 500 FT FUEL PUMP OFF
PERIODIC CHECKS EVERY 15 MINS
1. LOCATION CHECK
2. INSTRUMENTS SCAN
3. OIL PRESSURE 220-525 KPa
4. OIL TEMPERATURE 80-100°C
5. CYLINDER HEAD TEMPERATURE 150°C
6. FUEL CHECK
7. ELAPSED TIME CHECK
APPROACHING AN AIRFIELD
1. ENHANCED LOOKOUT AREA SAFE
2. ALTITUDE SET QNH
3. RUNWAY UN USE CHECK
4. WIND SOCK OBSERVE
DOWN WIND CHECKS
1. FUEL CHECK
2. FUEL PUMP ON
3. HARNESS SECURE
4. ALL CLEAR CHECK
5. WIND DIRECTION CHECK
6. THROTTLE AS REQUIRED
7. RADIO CALL
ON APPROACH
1. GLIDE SLOPE BEST GLIDE
2. TRIM SET
3. ALIGNMENT RUNWAY
4. SPEED 55 KTS
5. POWER 1500 RPM OR AS REQUIRED
6. RADIO CALL
7. AFTER LANDING FUEL PUMP OFF
SWITCHING OFF
1. RPM FOR 30 SECONDS 2200
2. RPM FOR 30 SECONDS IDLE
3. RADIO OFF
4. MAGNETOS OFF
5. MASTER OFF
LIMITATIONS
1. VA 71 KTS
2. VNE 102 KTS
3. VC 82 KTS
4. VR 45 KTS
5. VS 37 KTS
6. MANOEUVERS +4.0 & -2.0 G
7. MAX WIMD 25 KTS
8. MAX X-WIND 15 KTS
9. OIL AEROSHELL W MULTIGRADE 15 W-50 W
10. FUEL LEADED OR UNLEADED AUTO GAS
SPECIFICATIONS
1. WING SPAN 9.60 M
2. WING CHORD 1.56 M
3. WING AREA 14.94 SQR M
4. HEIGHT(FIN) 2.41 M
5. LENGTH 5.971 M
6. FUEL CAPACITY 50 L
7. OIL QUANTITY 2.3 L
